特殊润湿材料耦合离心处理含油乳化水的研究

doi:10.19965/j.cnki.iwt.2022-0252

摘要/Abstract

摘要：

针对含油污水处理领域中O/W型乳浊液净化分离困难的问题，构建了一种由超亲水/超亲油筛网膜、超疏水/超亲油海绵等特殊润湿性材料与离心力场相耦合的分离净化装置，并在验证装置分离净化效果的基础上，对处理条件和重要设计参数进行了考察。结果表明，经耦合分离装置处理后，不同来源O/W型乳浊液的水分离液纯度均达到99%以上，处理效果良好，且当处理温度为15~30 ℃，离心转速为1 800 r/min，材料轴心距为30 cm，处理时间为8 min时，装置处理效果最佳。温度升高使油、水和乳化剂间的互溶效果增强，促进它们的相互渗透和均匀分布，对系统的破乳分离过程不利；转速增大导致旋转液面的凹陷加深，油滴富集区位置与中心轴的距离增大，油滴与材料的接触减少，对破乳分离过程不利；当材料设置位置与油滴富集区位置接近时，油滴与分离材料的接触最多，分离效果最佳；延长处理时间虽然可以增强破乳分离效果，但过长的处理时间会导致处理成本增加。

关键词: 含油污水, 特殊润湿材料, 离心, 耦合, 破乳分离

Abstract:

It is difficult to achieve separation and purification of oil-in-water emulsion by a single method or unit in the field of oily sewage treatment. A device coupling special wetting materials and centrifugation were designed. Based on separation effect of the device was verified，some treatment conditions and design parameters were investigated. The results showed that purity of the water-phase reached above 99% after treatment，and the effects of separation and purification was good. Furthermore，the optimal treatment effect was obtained under the condition of 15-30 ℃，rotational speed 1 800 r/min，the distance between materials and central axis 30 cm，and the treatment time 8 min. It was because increasing temperature enhances the mutual dissolution between oil，water and emulsifier，promoted their mutual penetration and uniform distribution，which was unfavorable to the process of demulsification and separation. An increase in the rotational speed would result in deeper depression of the liquid surface，and increased the distance between the enrichment area of oil droplet and the central axis，and reduced the contact of the oil droplet and separation materials，which was bad for demulsification and separation. When the special wetting materials was set close to the enrichment area of oil droplet，the oil droplets had the most contact with the materials，and the separation effect was the best. The extended treatment time could enhance the effect of processing，but too long treatment time would lead to increase of treatment cost.

Key words: oily sewage, special wetting materials, centrifugation, coupling, demulsification and separation

中图分类号:

X703.3

吴云,龚海峰. 特殊润湿材料耦合离心处理含油乳化水的研究[J]. 工业水处理, 2023, 43(1): 145-150.

Yun WU,Haifeng GONG. Separation and purification of oily sewage by coupling special wetting materials and centrifugation[J]. Industrial Water Treatment, 2023, 43(1): 145-150.

https://gyscl.magtechjournal.com/CN/Y2023/V43/I1/145

图/表 10

图1 特殊润湿性材料耦合离心场破乳分离装置

Fig. 1 Diagram of separation device that coupled centrifugal field with special wetting materials

图2 制备得到的筛网膜表面特征

Fig. 2 Surface morphology and wettability of stainless steel meshes before and after processing in solution

图3 制备得到的硅烷化三聚氰胺海绵表面特征

Fig. 3 Surface characteristics of the silanization of a melamine sponge（SMS）

表1 不同来源含油乳化水水质

Table 1 Water quality of oily swages from different sources

样品编号	pH	COD/（mg·L^-1）	油/（g·L^-1）	SS/（mg·L^-1）	电导率/（mS·cm^-1）
1	7.3	31 600	53.96	212	0.21
2	5.8	56 820	82.63	126	1.73
3	9.2	38 500	68.92	60	1.23
4	11.8	29 300	45.68	320	2.60
5	7.1	88 900	104.36	236	1.36
6	6.8	48 600	72.16	165	2.29

图4 含油乳化水处理前后外观及显微观察照片
（a）处理前外观；（b）处理后外观；（c）处理前显微照片；（d）处理后显微照片。

Fig. 4 Photos of appearance and microscope before and after treatment

图5 温度对耦合装置分离效果的影响

Fig. 5 Influence of temperature on separation effect

图6 离心转速对耦合装置分离效果的影响

Fig. 6 Influence of centrifugation speed on separation effect

图7 不同转速下乳浊液在分离装置中的旋转形态

Fig. 7 Rotation form of emulsion in different centrifugation speed

图8 轴心距对耦合装置分离效果的影响

Fig. 8 Influence of axis distance on separation effect

图9 处理时间对耦合装置分离效果的影响

Fig. 9 Influence of treatment time on separation effect

参考文献 22

1	FENG Lin， ZHANG Zhongyi， Zhenhong MAI，et al. A super-hydrophobic and super-oleophilic coating mesh film for the separation of oil and water［J］. Angewandte Chemie（International Ed. in English），2004，43（15）：2012-2014. doi:10.1002/anie.200353381 doi: 10.1002/anie.200353381 URL
2	刘立新，谭小红，赵晓非，等. 疏水改性钢网对模拟化学驱油田污水破乳除油研究［J］. 工业水处理，2021，41（6）：257-261. doi:10.11894/iwt.2020-0843 doi: 10.11894/iwt.2020-0843 URL
	LIU Lixin， TAN Xiaohong， ZHAO Xiaofei，et al. Demulsification and oil removal of simulated chemical flooding oily wastewater by hydrophobic modified steel mesh［J］. Industrial Water Treatment，2021，41（6）：257-261. doi:10.11894/iwt.2020-0843 doi: 10.11894/iwt.2020-0843 URL
3	王永军，吕学良，郭海军. 疏水改性阳离子高分子絮凝剂的合成及其絮凝性能［J］. 工业水处理，2017，37（3）：85-88. doi:10.11894/1005-829x.2017.37(3).020 doi: 10.11894/1005-829x.2017.37(3).020 URL
	WANG Yongjun， Xueliang LÜ， GUO Haijun. Synthesis of the hydrophobic，modified，cationic，and polymeric flocculant and its flocculation capacity for wastewater［J］. Industrial Water Treatment，2017，37（3）：85-88. doi:10.11894/1005-829x.2017.37(3).020 doi: 10.11894/1005-829x.2017.37(3).020 URL
4	WENZEL R N. Resistance of solid surfaces to wetting by water［J］. Transactions of the Faraday Society，1936，28（8）：988-994. doi:10.1021/ie50320a024 doi: 10.1021/ie50320a024 URL
5	MONTGOMERY M A， ELIMELECH M. Water and sanitation in developing countries：Including health in the equation［J］. Environmental Science & Technology，2007，41（1）：17-24. doi:10.1021/es072435t doi: 10.1021/es072435t URL
6	XUE Zhongxin， CAO Yingze， LIU Na，et al. Special wettable materials for oil/water separation［J］. Journal of Materials Chemistry A，2014，2（8）：2445-2460. doi:10.1039/c3ta13397d doi: 10.1039/c3ta13397d URL
7	KONG Liang， WANG Qianqian， XIONG Sen，et al. Turning low-cost filter papers to highly efficient membranes for oil/water separation by atomic-layer-deposition-enabled hydrophobization［J］. Industrial & Engineering Chemistry Research，2014，53（42）：16516-16522. doi:10.1021/ie502864u doi: 10.1021/ie502864u URL
8	DU Chuan， WANG Jiadao， CHEN Zhifu，et al. Durable superhydrophobic and superoleophilic filter paper for oil/water separation prepared by a colloidal deposition method［J］. Applied Surface Science，2014，313：304-310. doi:10.1016/j.apsusc.2014.05.207 doi: 10.1016/j.apsusc.2014.05.207 URL
9	XUE Chaohua， JI Pengting， ZHANG Ping，et al. Fabrication of superhydrophobic and superoleophilic textiles for oil/water separation［J］. Applied Surface Science，2013，284：464-471. doi:10.1016/j.apsusc.2013.07.120 doi: 10.1016/j.apsusc.2013.07.120 URL
10	ZHOU Xiaoyan， ZHANG Zhaozhu， XU Xianghui，et al. Robust and durable superhydrophobic cotton fabrics for oil/water separation［J］. ACS Applied Materials & Interfaces，2013，5（15）：7208-7214. doi:10.1021/am4015346 doi: 10.1021/am4015346 URL
11	LI Xiong， WANG Min， WANG Ce，et al. Facile immobilization of Ag nanocluster on nanofibrous membrane for oil/water separation［J］. ACS Applied Materials & Interfaces，2014，6（17）：15272-15282. doi:10.1021/am503721k doi: 10.1021/am503721k URL
12	ZHOU Xiaoyan， ZHANG Zhaozhu， XU Xianghui，et al. Facile fabrication of superhydrophobic sponge with selective absorption and collection of oil from water［J］. Industrial & Engineering Chemistry Research，2013，52（27）：9411-9416. doi:10.1021/ie400942t doi: 10.1021/ie400942t URL
13	PHAM V H， DICKERSON J H. Superhydrophobic silanized melamine sponges as high efficiency oil absorbent materials［J］. ACS Applied Materials & Interfaces，2014，6（16）：14181-14188. doi:10.1021/am503503m doi: 10.1021/am503503m URL
14	KOTA A K， KWON G， CHOI W，et al. Hygro-responsive membranes for effective oil/water separation［J］. Nature Communications，2012，3：1025. doi:10.1038/ncomms2027 doi: 10.1038/ncomms2027 URL
15	ZHANG Feng， ZHANG Wen bin， SHI Zhun，et al. Nanowire-haired inorganic membranes with superhydrophilicity and underwater ultralow adhesive superoleophobicity for high-efficiency oil/water separation［J］. Advanced Materials，2013，25（30）：4192-4198. doi:10.1002/adma.201301480 doi: 10.1002/adma.201301480 URL
16	TAO Mimi， XUE Lixin， LIU Fu，et al. An intelligent superwetting PVDF membrane showing switchable transport performance for oil/water separation［J］. Advanced Materials，2014，26（18）：2943-2948. doi:10.1002/adma.201305112 doi: 10.1002/adma.201305112 URL
17	DUAN Chunting， ZHU Tang， GUO Jing，et al. Smart enrichment and facile separation of oil from emulsions and mixtures by superhydrophobic/superoleophilic particles［J］. ACS Applied Materials & Interfaces，2015，7（19）：10475-10481. doi:10.1021/acsami.5b01901 doi: 10.1021/acsami.5b01901 URL
18	SHI Heng， HE Yi， PAN Yang，et al. A modified mussel-inspired method to fabricate TiO₂ decorated superhydrophilic PVDF membrane for oil/water separation［J］. Journal of Membrane Science，2016，506：60-70. doi:10.1016/j.memsci.2016.01.053 doi: 10.1016/j.memsci.2016.01.053 URL
19	LI Hui， ZHAO Xiaoyun， WU Pengfei，et al. Facile preparation of superhydrophobic and superoleophilic porous polymer membranes for oil/water separation from a polyarylester polydimethylsiloxane block copolymer［J］. Journal of Materials Science，2016，51（6）：3211-3218. doi:10.1007/s10853-015-9632-6 doi: 10.1007/s10853-015-9632-6 URL
20	XIONG Zhu， LIN Haibo， LIU Fu，et al. Flexible PVDF membranes with exceptional robust superwetting surface for continuous separation of oil/water emulsions［J］. Scientific Reports，2017，7：14099. doi:10.1038/s41598-017-14429-2 doi: 10.1038/s41598-017-14429-2 URL
21	HUANG Meiling， SI Yang， TANG Xiaomin，et al. Gravity driven separation of emulsified oil/water mixtures utilizing in situ polymerized superhydrophobic and superoleophilic nanofibrous membranes［J］. Journal of Materials Chemistry A，2013，1（45）：14071. doi:10.1039/c3ta13385k doi: 10.1039/c3ta13385k URL
22	安静，周龙涛，贾悦，等. 新疆油田含油污泥破乳-离心脱水工艺优化［J］. 环境工程学报，2021，15（8）：2721-2729. doi:10.12030/j.cjee.202104046 doi: 10.12030/j.cjee.202104046 URL
	AN Jing， ZHOU Longtao， JIA Yue，et al. Process optimization of demulsification and centrifugal dewatering of oily sludge in Xinjiang oilfield［J］. Chinese Journal of Environmental Engineering，2021，15（8）：2721-2729. doi:10.12030/j.cjee.202104046 doi: 10.12030/j.cjee.202104046 URL

[1]	唐正, 张凯, 陈爱, 吕修颖, 李根, 马菁菁, 赵维, 张夏丽. 含盐废水处理技术前沿及低碳资源化研究进展[J]. 工业水处理, 2026, 46(3): 1-16.
[2]	王磊. 含对甲砜基苯甲酸高浓废水处理实例[J]. 工业水处理, 2025, 45(8): 202-206.
[3]	龚玉华, 沈莺, 朱玲, 张亚维, 徐雯雯, 李昆阳, 武超. 生物炭耦合Bacillus cereus YJ-2强化降解废水中苯系物研究[J]. 工业水处理, 2025, 45(4): 53-61.
[4]	伍启文, 巢真, 王喜昭, 徐莹, 陈思源, 韩红波, 文武, 田云. 多工艺耦合调控的污水处理厂应急扩建工程设计[J]. 工业水处理, 2025, 45(4): 186-193.
[5]	綦玥彤, 许路, 卫小嘉, 金鑫, 白雪, 石烜, 黄悦, 金鹏康. 光致Fenton氧化-混凝耦合工艺的镍皂废水有机物去除特性[J]. 工业水处理, 2025, 45(12): 55-64.
[6]	徐雪, 孙亚, 朱晓丹, 沈淑娟, 师亚威, 丁光辉. 含油污水电破乳技术研究进展[J]. 工业水处理, 2025, 45(10): 18-28.
[7]	王来春, 钱佳, 金凯, 许柯, 黄辉, 王庆. 内分泌干扰毒性深度削减关键技术及工艺研究[J]. 工业水处理, 2024, 44(8): 114-121.
[8]	隽鹏, 梁媛, 杜颖. 抽滤法测定海水基免混配聚合物压裂液残渣含量[J]. 工业水处理, 2024, 44(7): 179-184.
[9]	李冰, 吴迪, 石岩, 李海翔, 李甫, 马毅. 膜耦合技术对沼液浓缩及净水效果的影响[J]. 工业水处理, 2024, 44(5): 156-163.
[10]	范凤艳, 杨郭. 超支化聚合物破乳剂HPO-1在强乳化含油污水处理中的应用[J]. 工业水处理, 2024, 44(5): 185-191.
[11]	刘联胜, 屈惠茹, 霍鑫鹏, 李振祎, 段润泽, 解珺. 基于气泡雾化喷嘴的低能耗含油污水处理实验研究[J]. 工业水处理, 2024, 44(4): 105-112.
[12]	宋嘉庚, 周翔, 降科宇. 基于极化曲线法的铝阳极电化学性能研究[J]. 工业水处理, 2024, 44(4): 187-192.
[13]	王庆吉, 胡景泽, 孙秀梅, 李东, 陈曦, 李颖, 陆浩然, 王列, 魏炜. 石油石化含油废水混凝气浮处理系统研究进展[J]. 工业水处理, 2024, 44(3): 45-56.
[14]	史楚儿, 邱兆富, 金锡标, 王远. 两级A/O+铁盐耦合沉淀组合工艺处理酞菁铜生产废水[J]. 工业水处理, 2024, 44(2): 177-183.
[15]	王海攀, 谷明川, 李洪涛, 靳海涛, 戴威. IFAS工艺处理尼龙66帘子布生产废水[J]. 工业水处理, 2023, 43(7): 207-211.

选择文件类型/文献管理软件名称

选择包含的内容